Contents
1 The Noise Problem
2 Effects of Noise
2.1 Hearing Loss
2.2 Noise Interference
2.3 Sleep Disturbance
2.4 Noise Influence on Health
3 Noise Sources
3.1 Jet Noise
3.2 Turbomachinery Noise
4 Noise Measurement and Rules
4.1 Noise Effectiveness Forecast (NEF)
4.2 Effective Perceived Noise Level (EPNL)
5 Noise Certification
5.1 Noise limits
6 Calculations
6.1 Tupolev 154M Description
6.2 Noise calculations
6.2.1 Take-off Noise Calculation
6.2.2 Landing Approach Noise Claculation
7 Noise Suppression
7.1 Jet Noise Suppression
7.2 Duct Linings
7.2.1 Duct Lining Calculation
1 The Noise Problem
Though long of concern to neighbors of major airports, aircraft noise first became a major problem with the introduction of turbojet-powered commercial aircraft (Tupolev 104, Boeing 707, Dehavilland Comet) in the late 1950s. It was recognized at the time that the noise levels produced by turbojet powered aircraft would be unacceptable to persons living under the take-off pattern of major airports. Accordingly, much effort was devoted to developing jet noise suppressors, with some modest success. Take-off noise restrictions were imposed by some airport managements, and nearly all first-generation turbojet-powered transports were equipped with jet noise suppressors at a significant cost in weight, thrust, and fuel consumption.
The introduction of the turbofan engine, with its lower jet velocity, temporarily alleviated the jet noise problem but increased the high-frequency turbomachinery noise, which became a severe problem on landing approach as well as on take-off. This noise was reduced somewhat by choosing proper rotor and stator blade numbers and spacing and by using engines of the single-mixed-jet type.
2 Effects Of Noise
Noise is often defined as unwanted sound. To gain a satisfactory understanding of the effects of noise, it would be useful to look briefly at the physical properties of sound.
Sound is the result of pressure changes in a medium, caused by vibration or turbulence. The amplitude of these pressure changes is stated in terms of sound level, and the rapidity with which these changes occur is the sound's frequency. Sound level is measured in decibels (dB), and sound frequency is stated in terms of cycles per second or Hertz (Hz). Sound level in decibels is a logarithmic rather than a linear measure of the change in pressure with respect to a reference pressure level. A small increase in decibels can represent a large increase in sound energy. Technically, an increase of 3 dB represents a doubling of sound energy, and an increase of 10 dB represents a tenfold increase. The ear, however, perceives a 10-dB increase as doubling of loudness.
Another important aspect is the duration of the sound, and the way it is distributed in time. Continuous sounds have little or no variation in time, varying sounds have differing maximum levels over a period of time, intermittent sounds are interspersed with quiet periods, and impulsive sounds are characterized by relatively high sound levels and very short durations.
The effects of noise are determined mainly by the duration and level of the noise, but they are also influenced by the frequency. Long-lasting, high-level sounds are the most damaging to hearing and generally the most annoying. High-frequency sounds tend to be more hazardous to hearing and more annoying than low-frequency sounds. The way sounds are distributed in time is also important, in that intermittent sounds appear to be somewhat less damaging to hearing than continuous sounds because of the ear's ability to regenerate during the intervening quiet periods. However, intermittent and impulsive sounds tend to be more annoying because of their unpredictability.
Noise has a significant impact on the quality of life, and in that sense, it is a health problem. The definition of health includes total physical and mental well-being, as well as the absence of disease. Noise is recognized as a major threat to human well-being.
The effects of noise are seldom catastrophic, and are often only transitory, but adverse effects can be cumulative with prolonged or repeated exposure. Although it often causes discomfort and sometimes pain, noise does not cause ears to bleed and noise-induced hearing loss usually takes years to develop. Noise-induced hearing loss can indeed impair the quality of life, through a reduction in the ability to hear important sounds and to communicate with family and friends. Some of the other effects of noise, such as sleep disruption, the masking of speech and television, and the inability to enjoy one's property or leisure time also impair the quality of life. In addition, noise can interfere with the teaching and learning process, disrupt the performance of certain tasks, and increase the incidence of antisocial behavior. There is also some evidence that it can adversely affect general health and well-being in the same manner as chronic stress.
2.1 Hearing Loss
Hearing loss is one of the most obvious and easily quantified effects of excessive exposure to noise. Its progression, however, is insidious, in that it usually develops slowly over a long period of time, and the impairment can reach the handicapping stage before an individual is aware of what has happened.
Prolonged exposure to noise of a certain frequency pattern can cause either temporary hearing loss, which disappears in a few hours or days, or permanent loss. The former is called temporary threshold shift , and the latter is known as permanent threshold shift .
Temporary threshold shift is generally not damaging to human’s ear unless it is prolonged. People who work in noisy environments commonly are victims of temporary threshold shift.
Figure 2.1 Temporary threshold shift for rock band performers.
Repeated noise over a long time leads to permanent threshold shift. This is especially true in industrial applications where people are subjected to noises of a certain frequency.
There is some disagreement as to the level of noise that should be allowed for an 8-hour working day. Some researchers and health agencies insist that 85 dB(A) should be the limit. Industrial noise level limitations are shown in the Table 2.1.
Table 2.1 Maximum Permissible Industrial Noise Levels By OSHA
(Occupational Safety and Health Act)
| Sound Level, dB(A) |
Maximum Duration During Any Working Day (hr) |
| 90 |
8 |
| 92 |
6 |
| 95 |
4 |
| 100 |
2 |
| 105 |
1 |
| 110 |
½ |
| 115 |
¼ |
Noise-induced hearing loss is probably the most well-defined of the effects of noise. Predictions of hearing loss from various levels of continuous and varying noise have been extensively researched and are no longer controversial. Some discussion still remains on the extent to which intermittencies ameliorate the adverse effects on hearing and the exact nature of dose-response relationships from impulse noise. It appears that some members of the population are somewhat more susceptible to noise-induced hearing loss than others, and there is a growing body of evidence that certain drugs and chemicals can enhance the auditory hazard from noise.
Although the incidence of noise-induced hearing loss from industrial populations is more extensively documented, there is growing evidence of hearing loss from leisure time activities, especially from sport shooting, but also from loud music, noisy toys, and other manifestations of our "civilized" society. Because of the increase in exposure to recreational noise, the hazard from these sources needs to be more thoroughly evaluated. Finally, the recent evidence that hearing protective devices do not perform in actual use the way laboratory tests would imply, lends support to the need for reevaluating current methods of assessing hearing protector attenuation.
2.2 Noise Interference
Noise can mask important sounds and disrupt communication between individuals in a variety of settings. This process can cause anything from a slight irritation to a serious safety hazard involving an accident or even a fatality because of the failure to hear the warning sounds of imminent danger. Such warning sounds can include the approach of a rapidly moving motor vehicle, or the sound of malfunctioning machinery. For example, Aviation Safety states that hundreds of accident reports have many "say again" exchanges between pilots and controllers, although neither side reports anything wrong with the radios.
Noise can disrupt face-to-face and telephone conversation, and the enjoyment of radio and television in the home. It can also disrupt effective communication between teachers and pupils in schools, and can cause fatigue and vocal strain in those who need to communicate in spite of the noise. Interference with communication has proved to be one of the most important components of noise-related annoyance.
Interference with speech communication and other sounds is one of the most salient components of noise-induced annoyance. The resulting disruption can constitute anything from an annoyance to a serious safety hazard, depending on the circumstance.
Criteria for determining acceptable background levels in rooms have also been expanded and refined, and progress has been made on the development of effective acoustic warning signals.
It is now dear that hearing protection devices can interfere with the perception of speech and warning signals, especially when the listener is hearing impaired, both talker and listener wear the devices, and when wearers attempt to locate a signal's source.
Noise can interfere with the educational process, and the result has been dubbed "jet-pause teaching" around some of the nation's noisier airports, but railroad and traffic noise can also produce scholastic decrements.
2.3 Sleep Disturbance
Noise is one of the most common forms of sleep disturbance, and sleep disturbance is a critical component of noise-related annoyance. A study used by EPA in preparing the Levels Document showed that sleep interference was the most frequently cited activity disrupted by surface vehicle noise (BBN, 1971). Aircraft none can also cause sleep disruption, especially in recent years with the escalation of nighttime operations by the air cargo industry. When sleep disruption becomes chronic, its adverse effects on health and well-being are well-known.
Noise can cause the sleeper to awaken repeatedly and to report poor sleep quality the next day, but noise can also produce reactions of which the individual is unaware. These reactions include changes from heavier to lighter stages of sleep, reductions in "rapid eye movement" sleep, increases in body movements during the night, changes in cardiovascular responses, and mood changes and performance decrements the next day, with the possibility of more serious effects on health and well-being if it continues over long periods.
2.4 Noise Influence on Health
Noise has been implicated in the development or exacerbation of a variety of health problems, ranging from hypertension to psychosis. Some of these findings are based on carefully controlled laboratory or field research, but many others are the products of studies that have been severely criticized by the research community. In either case, obtaining valid data can be very difficult because of the myriad of intervening variables that must be controlled, such as age, selection bias, preexisting health conditions, diet, smoking habits, alcohol consumption, socioeconomic status, exposure to other agents, and environmental and social stressors. Additional difficulties lie in the interpretation of the findings, especially those involving acute effects.
Loud sounds can cause an arousal response in which a series of reactions occur in the body. Adrenalin is released into the bloodstream; heart rate, blood pressure, and respiration tend to increase; gastrointestinal motility is inhibited; peripheral blood vessels constrict; and muscles tense. Even though noise may have no relationship to danger, the body will respond automatically to noise as a warning signal.
3 Noise Sources
All noise emanates from unsteadiness – time dependence in the flow. In aircraft engines there are three main sources of unsteadiness: motion of the blading relative to the observer, which if supersonic can give rise to propagation of a sequence of weak shocks, leading to the “buzz saw” noise of high-bypass turbofans; motion of one set of blades relative to another, leading to a pure-tome sound (like that from siren) which was dominant on approach in early turbojets; and turbulence or other fluid instabilities, which can lead to radiation of sound either through interaction with the turbomachine blading or other surfaces or from the fluid fluctuations themselves, as in jet noise.
3.1 Jet Noise
When fluid issues as a jet into a stagnant or more slowly moving background fluid, the shear between the moving and stationary fluids results in a fluid-mechanical instability that causes the interface to break up into vortical structures as indicated in Fig. 3.1. The vortices travel downstream at a velocity which is between those of the high and low speed flows, and the characteristics of the noise generated by the jet depend on whether this propagation velocity is subsonic or supersonic with respect to the external flow. We consider first the case where it is subsonic, as is certainly the case for subsonic jets.
Figure 3.1 A subsonic jet mixing with ambient air, showing the mixing layer
followed by the fully developed jet.
For the subsonic jets the turbulence in the jet can be viewed as a distribution of quadrupoles.
3.2 Turbomachinery Noise
Turbomachinery generates noise by producing time-dependent pressure fluctuations, which can be thought of in first approximation as dipoles since they result from fluctuations in force on the blades or from passage of lifting blades past the observer.
It would appear at first that compressors or fans should not radiate sound due to blade motion unless the blade tip speed is supersonic, but even low-speed turbomachines do in fact produce a great deal of noise at the blade passing frequencies.
4 Noise Measurement and Rules
Human response sets the limits on aircraft engine noise. Although the logarithmic relationship represented by the scale of decibels is a first approximation to human perception of noise levels, it is not nearly quantitative enough for either systems optimization or regulation. Much effort has gone into the development of quantitative indices of noise.
4.1 Noise Effectiveness Forecast (NEF)
It is not the noise output of an aircraft per se that raises objections from the neighborhood of a major airport, but the total noise impact of the airport’s operations, which depends on take-off patterns, frequencies of operation at different times of the day, population densities, and a host of less obvious things. There have been proposals to limit the total noise impact of airports, and in effect legal actions have done so for the most heavily used ones.
One widely accepted measure of noise impact is the Noise Effectiveness Forecast (NEF), which is arrived at as follows for any location near an airport:
1. For each event, compute the Effective Perceived Noise Level (EPNL) by the methods of ICAO Annex 16, as described below.
2. For events occurring between 10 PM and 7 AM, add
28-04-2015, 23:26